Page 22 RS-500/600 Door Part No 4801-5166 Rev 01-2015
12 Egress Strap Removal/Re-Installation
12.1 Removal
1. Locate the door controller and turn off the power switch on the left side of the controller.
2. Remove the door’s head unit cover.
3. Place the door in the JOG mode by holding the Up and down arrows on the controller at the same
time until you see “JOG” in the controller’s display.
Warning!
Watch the panel closely while you are slowly jogging/rolling the curtain up on the drive shaft.
Stop when you see the area where the long egress strap is connected to the short egress
piece attached to a triangle panel. This should bring the strap and connection point, right to
the top for easy access. Failure to stop can cause curtain to reverse direction and damage
door components.
4. Find the area where 2 loops are attached with a quick-link, unscrew the quick-link that attaches the
long yellow strap loop to the yellow loop of the triangle piece. Make sure not to drop the weight into
the door.
5. Access the inside area of the cooler/freezer box through the door opening. If the strap is hanging
inside, unhook and remove the gold buckle and the damaged yellow strap (top center of door) from
the door.
12.2 Installation
1. Locate the door controller and turn off the power switch on the left side of the controller.
2. Remove the door head unit cover.
3. Un-roll the yellow egress strap with attached gold buckle.
NOTE: Insert the strap through the hole in the center of the door, near the top, where original strap was
traveling down inside the curtain and replace the old gold buckle with the new one.
4. Proceed to the outside area and locate the roller assembly at the top center of the door where the
original strap came into the curtain area from the inside cooler/freezer area. Use anything with some
stiffness (banding material) and feed the stiff item through the roller and down through the slot
located in the inside cooler/freezer area and tape or tie it to the small loop (not the D-ring) of the
yellow strap. Then gently pull it through the hole and roller assembly at the top/center of the door.
5. Ensure the yellow strap is not twisted. Place the counter weight onto the yellow strap.
6. Attach the new strap (small loop) that you just pulled into the curtain area to the (small loop) strap on
the triangle piece of panel using the quick-link.
7. Attach the gold buckle to the door frame.
8. With the controller still in JOG mode, use the down arrow to lower the door to the floor. Exit JOG
mode by holding the Up and Down arrows on the controller at the same time until you see “---” in
the display of the controller.
9. Press “Open” button. If the Door is set to automatically close, door will time out and automatically
close if safety beams are clear. If the Door is set to manually close, press “Close” button and door
should close.
Note: If you detect any problems, STOP. Disconnect electrical power. Contact your
distributor for assistance.
10. Press “Open” (and “Close” if required) a several times to insure proper operation.
11. Re-attach the cover.
!
(16 pages)
(50 pages)
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Commentaires sur ces manuels